Return to flip book view

SAFETY DATA SHEETGET COATEDAGGREGATEinfo@flexrockcoatings.com | 800-808-0414 | FlexRockCoatings.comHIGH WEAR ADDITIVEHIGH WEAR ADDITIVETabular Aluminum

SAFETY DATA SHEET PRODUCT CODE: HWS additive PAGE 1 OF 3 SECTION 1: PRODUCT AND COMPANY IDENTIFICATION PRODUCT NAME: HWS Additive PRODUCT CODES: HWS Additive MANUFACTURER: National Polymers Inc. STREET ADDRESS: 9 Guttman Avenue CITY, STATE, ZIP: Charleroi, Pa. 15022 INFORMATION PHONE: 724-483-9300 EMERGENCY PHONE: Chemtrec 800-424-9300 FAX PHONE: 724-483-9306 PREPARED BY: Harry Jackson DATE REVISED: 4/15/15 Chemical Name or Class: Tabular alumina SECTION 2: HAZARDS IDENTIFICATION Hazard Overview GHS Classification: Not classified as dangerous according to the regulations GHS Label Elements and Precautionary Statements: Label Elements: None Hazard Statements: P102 Keep out of reach of children. P103 Read label before use Precautionary statements: None Other Non-Classifiable hazards information Hazard Statements: P261: Avoid breathing dust/fume/gas/mist/vapors/spray P280: Wear Eye Protection/face protection P285: In case of inadequate ventilation, use respiratory protection. Precautionary statements: P305+P351+P338: If in eyes: Rinse cautiously with water for several minutes. Remove contact lense, if present and easy to do. Continue rinsing. P302+P352: If on skin, wash with plenty of soap and water. HMIS HAZARD CLASSIFICATION HEALTH: 1 FLAMMIBILITY: 0 REACTIVITY: 0 PERSONAL PROTECIVE EQUIPMENT: E POTENTIAL HEALTH EFFECTS EYES: MAY CAUSE REDDENING OF THE EYES OR EYE IRRITATION FROM AIRBORNE PARTICLES SKIN: NONE KNOWN INGESTION: NONE KNOWN INHALATION: NO DATA AVAILABLE HEALTH HAZARDS (ACUTE AND CHRONIC): INHALATION OF DUST GENERATED MAY AGGREVATE PRE-EXISTING CONDITIONS MEDICAL CONDITIONS GENERALLY AGGRAVATED BY EXPOSURE: PULMONARY CONDITIONS OR OTHER SIMILAR AILMENTS CAN BE AGGREVATED BY EXPOSURE. CARCINOGENICITY OSHA: NO NTP: NO IARC: NO NO CARCINOGENICITY PROPERTIES ARE KNOWN TO EXIST. SECTION 3: COMPOSITION/INFORMATION ON INGREDIENTS INGREDIENT CAS NO. OSHA PEL ACGIH TLV OSHA STEL WEIGHT % Tabular Alumina 1344-28-1 10mg/m3 10mg/m3 20mg/m3 100***No toxic chemical(s) subject to the reporting requirements of section 313 of Title III and of 40 CFR 372 are present.***

SAFETY DATA SHEET PRODUCT CODE: HWS additive PAGE 2 OF 3 FOLLOW OSHA HAZARD COMMUNICATION RULE 29CFR SECTIONS 1910.1200, 1915.99, 1917.28, 1918.9, 1926.59, AND STATE AND LOCAL COMMUNITY RIGHT TO KNOW LAWS. SECTION 4: FIRST AID MEASURES EYES: FLUSH EYES WITH WATER FOR AT LEAST FIFTEEN MINUTES AND CONSULT A PHYSICIAN IF CONDITION WARRANTS.SKIN: SKIN CONTACT WILL NORMALLY CAUSE NO HEALTH RISKS. INGESTION: IF INGESTED, CONSULT A PHYSICIAN. INHALATION: REMOVE VICTIM TO FRESH AIR AREA AND ADMINISTER OXYGEN IF NECESSARY. SECTION 5: FIRE-FIGHTING MEASURES FLAMMABLE LIMITS IN AIR, UPPER: n/a (% by volume) LOWER: n/a FLASH POINT: n/a METHOD USED: n/aEXTINGUISHING MEDIA: none known SPECIAL FIRE FIGHTING PROCEDURES: Tabular Alumina is neither a fire hazard nor an explosion hazard UNUSUAL FIRE AND EXPLOSION HAZARDS: No unusual fire hazards known. SECTION 6: RELEASE MEASURES STEPS TO BE TAKEN IN CASE MATERIAL IS RELEASED OR SPILLED: WEAR RESPIRATOR AND USE DUSTLESS HANDLING EQUIPMENT TO CLEAN UP LARGE SPILLS. PLACE IN SUITABLE DISPOSAL CONTAINERS. FLUSH AREA WITH WATER TO REMOVE RESIDUE. SECTION 7: HANDLING AND STORAGE PRECAUTIONS TO BE TAKEN IN HANDLING AND STORAGE: STORE IN COOL DRY PLACE. SEAL ALL PARTIALLY USED CONTAINERS. PROPERLY LABEL ALL CONTAINERS. AVOID BREATHING ANY DUST WHEN WORKING WITH THIS MATERIAL. OTHER PRECAUTIONS: AVOID BREATHING DUST GENERATED FROM THE MATERIAL. OBSERVE CONDITIONS OF GOOD GENERAL HYGIENE AND SAFE WORKING PRACTICES. PROVIDE TRAINING FOR YOUR EMPLOYEES RELATING TO OCCUPATIONAL EXPOSURE TO DUST. SECTION 8: EXPOSURE CONTROLS/PERSONAL PROTECTION RESPIRATORY PROTECTION: USE A NIOSH APPROVED RESPIRATOR OR DUST MASK AS REQUIRED TO PREVENT OVER-EXPOSURE TO DUST. PROVIDE SUFFICIENT EXHAUST TO KEEP EXPOSURE LEVELS BELOW THE ACGIH PEL. VENTILATION: USE EXHAUST SUFFICIEINT TO MAINTAIN AIRBORNE PARTICULATES BELOW THE ACGIH PEL LIMITS ESTABLISHED. PROTECTIVE GLOVES: N/A EYE PROTECTION: SPLASH PROOF GOGGLES OR SAFETY GLASSES WITH SIDE SHIELDS. OTHER PROTECTIVE CLOTHING OR EQUIPMENT: PROVIDE ANY EQUIPMENT NECESSARY TO PREVENT THE INHALATION OF DUST. WORK HYGIENIC PRACTICES: OBSERVE GOOD GENERAL HYGENIC PRACTICES. SEE SECTION THREE FOR OCCPATIONAL EXPOSURE LIMIT VALUES. SECTION 9: PHYSICAL AND CHEMICAL PROPERTIES APPEARANCE AND ODOR: White Powder form BOILING POINT OR RANGE: n/a VAPOR DENSITY (AIR = 1): n/a SPECIFIC GRAVITY (H2O = 1): 1.5EVAPORATION RATE: n/a SOLUBILITY IN WATER: insolubleOdor Threshhold: N/A

SAFETY DATA SHEET PRODUCT CODE: HWS additive PAGE 3 OF 3 pH: N/A Melting point/freezing point: N/A Vapor Pressure: N/A Auto Ignition Temperature: N/A Partition Coefficient: n-octanol/water: N/A Decomposition Temperature: N/A SECTION 10: STABILITY AND REACTIVITY STABILITY: STABLE CONDITIONS TO AVOID (STABILITY): None Known. INCOMPATIBILITY (MATERIAL TO AVOID): CAN REACT WITH STRONG OXIDIZING AGENTS. HAZARDOUS DECOMPOSITION OR BY-PRODUCTS: none known. HAZARDOUS POLYMERIZATION: WILL NOT OCCUR SECTION 11: TOXICOLOGICAL INFORMATION Component Tabular Alumina CAS# 1334-28-1: Special Remarks on Chronic Effects on Humans: May cause cancer (tumorigenic) according to animal data. No human data found. Special Remarks on other Toxic Effects on Humans: Acute Potential Health Effects: Skin: May cause skin irritation. Eyes: Nuissance Dust. Dust may cause mechanical eye irritation. Inhalation: Nuissance Dust. Material is irritating to mucous membranes and upper respiratory tract. May cause lung injury. Ingestion: May be harmful if swallowed. Ingestion of large amounts mat cause gastrointestinal tract irritation. It is expected to be a low hazard for normal industrial handling. SECTION 12: ECOLOGICAL INFORMATION Component Tabular Alumina CAS# 1334-28-1: Products of Biodegradation:Possibly hazardous short term degradation products are not likely. However, long term degradation products may arise Toxicity of the Products of Biodegradation: The product itself and its products of degradation are not toxic. SECTION 13: WASTE DISPOSAL WASTE DISPOSAL METHOD: DISPOSE OF THE MATERIAL IN A WASTE DISPOSAL SITE IN ACCORDANCE WITH LOCAL, STATE, AND FEDERAL LAWS. SECTION 14: Transport Information DOT: Not RegulatedIMO/IMDG Not regulated SECTION 15: REGULATORY INFORMATION Component Tabular Alumina CAS# 1334-28-1: Federal and State Regulations: Illinois toxic substances disclosure to employee act: Aluminum oxide Rhode Island RTK hazardous substances: Aluminum oxide Minnesota: Aluminum oxide Massachusetts RTK: Aluminum oxide New Jersey: Aluminum oxide New Jersey spill list: Aluminum oxide California Director's list of Hazardous Substances: Aluminum oxide TSCA 8(b) inventory: Aluminum oxide SARA 313 toxic chemical notification and release reporting: Aluminum oxide Other Regulations: EINECS: This product is on the European Inventory of Existing Commercial Chemical Substances. Other Classifications: WHMIS (Canada): Not controlled under WHMIS (Canada). DSCL (EEC): R36/38- Irritating to eyes and skin. S2- Keep out of the reach of children. S46- If swallowed, seek medical advice immediately SECTION 16: OTHER INFORMATION DISCLAIMER: The information Contained herein is based on the data available and is believed to be accurate, However, the manufacturer makes no warranty expressed or implied regarding the accuracy of this data or the results obtained from the use thereof. Accordingly, we assume no responsibility for injury from the use of this product. N/A = Not Available See Section 1 for date of preparation